Product ID:MIL-C-227 50F B-COMPONENT ORGANIC COATING F-09P400
MSDS Date:01/23/1996
FSC:8010
NIIN:01-314-2533
Status Code:A
Kit Part:Y
MSDS Number: CJDXL

Emergency Phone: (804) 397-2223

Info Phone: (804) 397-2223

Cage: 60163

Telephone: 757-397-2223

Cage: 60163

96.0 MM HG

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CAUSES NOSE AND THROAT IRRITATION. CAUSES
EYE IRRITATION. CAUSES SKIN I RRITATION. REPEATED & PROLONGED
OVEREXPOSURE TO SOLVENTS COULD CAUSE PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
INHALING CONTENTS MAY BE HARMFUL OR FAT AL.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT A
PHYSICIAN. EYE AND SKIN: IMMEDIATELY FLUSH EYES OR SKIN WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED
CLOTHING /SHOES. GET IMMEDIATELY MEDICAL ATTENTION WASH CLOTHING
BEFORE REUSE. DESTORY SHOES. INGESTION: GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point Method:SCC
Flash Point:=17.2C, 63.F
Lower Limits:2.0%
Upper Limits:12.0%
Extinguishing Media:ALCOHOL, DRY CHEMICAL, WATER, FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF WATER IS USED
FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE AND CAUSE FLASH FIRE. ISOLATE FROM
HEAT, SPARKS, ELECTRICAL EQUIPMENT, APPLIANCES, PILOT LIGHTS,
FLAMES AND OTHER SOURCES OF IGNITION. FLAMMABLE LIQUID AND VAPOR.

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF E.P.A.
AND OTHER LOCAL, STATE, AND FEDERAL AUTHORITIES.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
STORE IN COOL DRY AREA WITH VENTILATION SUITABLE FOR STORING
MATERIALS SHOWN IN INGREDIENTS SECTIO N.
Other Precautions:GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZARDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:NIOSH APPROVED RESP TYPES SUITABLE FOR MATLS IN
INGRED REC. APPROVED CHEM/MECH FILTERS RECOMMENDED WHEN VENTILATION
IS RESTRICTED. DO NOT BREATH (DUST, VAPORS OR SPRAY MIST). WEAR
APPROPRIATE RESP ( NIOSH APPROVED) DURING & AFTER APPLICATION
UNLESS AIR MONITORING RECORDS VAPOR/MIST LEVELS BELOW APPLICABLE
LIMITS. FOLLOW RESP MFR DIRECTIONS FOR USE.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN. SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PERMISSIBLE EXPOS
LIMIT/ACGIH'S TLV LIMIT. USE W/ADEQ VENT.
Protective Gloves:CHEMICAL RESISTANT, PLASTIC OR RUBBER.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER . AS
REQUIRED TO AVOID WETTING CLOTHING. USE PROTECTIVE CREAMS WHERE
SKIN CONTACT IS LIKELY. REMOVE AND WASH CONTAMINATED CLOTHING
BEFORE REUSE.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

Boiling Pt:>79.4C, 175.F
B.P. Text:175-401 F
Vapor Pres:SEE INGREDIENTS
Vapor Density:HVR/AIR
Spec Gravity:1.55
VOC Pounds/Gallon:344
VOC Grams/Liter:2.87
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume:41.8%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE, AND FEDERAL REGULATIONS.

Transport Information:DOT: FLAMMABLE LIQUID OR SOLID.

Federal Regulatory Information:OSHA: FLAMMABLE LIQUID CLASS III.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.